Hyundai Veloster Manuals

Hyundai Veloster: Specifications - General Information - Driveshaft and axleHyundai Veloster: Specifications

Hyundai Veloster 2011-2017 Service Manual / Driveshaft and axle / General Information / Specifications

Specification

Engine
 TM
 Joint type
 Max. permissible angle
Outer
 Inner
 Outer
 Inner
Gamma  1.6 GDI
 6 MT
 BJ#22
 TJi#22
 46.5°
 23°
6 DCT
 BJ#24
 TJi#22
Gamma  1.6 T-GDI
 6 MT
 BJ#23
 TJi#23
6 A/T
 BJ#24
 TJi#24

Tightening torque
Item
 N.m
 kgf.m
 lb-ft
Front
 Wheel Hub nuts
 88.2 ~ 107.8
 9.0 ~ 11.0
 65.0 ~ 79.5
Driveshaft caulking nut
 196.1 ~ 274.5
 20.0 ~28.0
 144.6 ~ 202.5
Strut assembly to knuckle
 137.3 ~ 156.9
 14.0 ~ 16.0
 101.3 ~ 115.7
Lower arm to knuckle
 78.5 ~ 88.3
 8.0 ~ 9.0
 57.9 ~ 65.1
Tie rod end castle nut
 23.5 ~ 33.3
 2.4 ~ 3.4
 19.4 ~ 24.5
Front caliper to knuckle
 78.4 ~ 98.0
 8.0 ~ 10.0
 57.8 ~ 72.3
Disc fixing screw
 4.9 ~ 5.8
 0.5 ~ 0.6
 3.6 ~ 4.3
Wheel speed sensor & bracket
 7.8 ~ 11.8
 0.8 ~ 1.2
 5.8 ~ 8.7
Rear
 Wheel Hub nuts
 88.2 ~ 107.8
 9.0 ~ 11.0
 65.0 ~ 79.5
Rear caliper mounting bolt
 63.7 ~ 73.5
 6.5 ~ 7.5
 47.0 ~ 54.2
Rear axle to torsion beam axle
 49.0 ~ 58.8
 5.0 ~ 6.0
 36.1 ~ 43.3
Disc fixing screw
 4.9 ~ 5.8
 0.5 ~ 0.6
 3.6 ~ 4.3
Wheel speed sensor & bracket
 4.9 ~ 5.9
 0.7 ~ 1.1
 5.1 ~ 8.0

Replace self-locking nuts with new ones after removal.

Lubricants

Engine
 Joint type
 Lubricants
 Quantity
Gamma  1.6 GDI (MT)
 BJ#22
 RBA
 90g
TJ#22
 CW09-VX21
 135g
Gamma  1.6 GDI (DCT)
 BJ#22
 RBA
 90g
TJi#22
 CW09-VX21
 135g
Gamma  1.6 T-GDI (MT)
 BJ#23
 RBA
 90g
TJi#23
 CW09-VX21
 140g
Gamma  1.6 T-GDI (AT)
 BJ#24
 RBA
 100g
TJi#24
 CW09-VX21
 145g


General Information
...

Special Service Tools
Special Service Tools Tool(Number and Name) Illustration Use 09495-3K000 Band installer Installation of ear type bo ...

See also:

Smooth cornering
Avoid braking or gear changing in corners, especially when roads are wet. Ideally, corners should always be taken under gentle acceleration. If you follow these suggestions, tire wear will be he ...

Specifications
Specifications Item Specification Power source DC 14.4V (-) ground Frequency range FM : 87.5 ~ 107.9 MHz / 200 kHz ...

Air bag - advanced supplemental restraint system
(1) Driver’s front air bag (2) Passenger’s front air bag (3) Side impact air bag (4) Curtain air bag WARNING Even in vehicles with air bags, you and your passengers must always wear the se ...

Categories

© 2011-2025 Copyright www.hvmanual.com