Hyundai Veloster Manuals

Hyundai Veloster: Seat Belt Pretensioner (BPT). Repair procedures - Seat Belt Pretensioner - Restraint (Advanced)Hyundai Veloster: Seat Belt Pretensioner (BPT). Repair procedures

Hyundai Veloster 2011-2017 Service Manual / Restraint (Advanced) / Seat Belt Pretensioner / Seat Belt Pretensioner (BPT). Repair procedures

Removal

1.
Disconnect the battery negative cable, and wait for at least three minutes before beginning work.
2.
Remove the seat belt after pushing the lock pin (A).

3.
Remove the following parts.
(Refer to the Body group - "Interior trim")
A.
Door scuff trim
B.
Center pillar trim
4.
Remove the upper anchor bolt.
5.
Disconnect the seat belt pretensioner connector (A).

6.
Loosen the seat belt pretensioner mounting bolts (B,C) and remove the seat belt pretensioner.

Installation

1.
Remove the ignition key from the vehicle.
2.
Disconnect the battery negative cable and wait for at least three minutes.
3.
Install the seat belt pretensioner with a bolts (B, C).

Tightening torque [Bolt B]:
39.2 ~ 54.0 N.m (4.0 ~ 5.5 kgf.m, 28.9 ~ 39.8 lb-ft)

4.
Connect the seat belt pretensioner (BPT) connector (A).
5.
Install the upper anchor bolts.

Tightening torque:
39.2 ~ 54.0 N.m (4.0 ~ 5.5 kgf.m, 28.9 ~ 39.8 lb-ft)

6.
Install the following parts.
(Refer to the Body group - "Interior trim")
A.
Center pillar trim
B.
Door scuff trim
7.
Insert seat belt to the anchor pretensioner.
Make sure the lock pin is connected in properly.
8.
Reconnect the battery negative cable.
9.
After installing the seat belt pretensioner, confirm proper system operation:
A.
Turn the ignition switch ON; the SRS indicator light should be turned on for about six seconds and then go off.

Seat Belt Pretensioner (BPT). Components and Components Location
Components ...

Anchor Pretensioner (APT). Description and Operation
Description Front anchor pretensioner operates as well as Belt Pretensioner at the same time If it gets into its deploy condition after a collision. It is located at near anchor on driver se ...

See also:

Closing the tailgate
To close the tailgate, lower and push down the tailgate firmly. Make sure that the tailgate is securely latched. WARNING - Exhaust fumes If you drive with the tailgate open, you will draw danger ...

Specifications
Specifications Items Specifications Clutch operation method Hydraulic type Clutch cover  Type Diaphr ...

Side Airbag (SAB) Module. Description and Operation
Description The Side Airbags (SAB) are installed inside the front seat and protects the driver and passenger from danger when side crash occurs. The SRSCM determines deployment of side airba ...

Categories


В© 2011-2024 Copyright www.hvmanual.com